METAL AIR WATER SYRINGE TIP
Infection control and sanitation are critical concerns for every dental surgery. An often-overlooked item is the air water syringe tip. Preventing cross-contamination requires specific protocols and air water syringe tips are no exception.
The air water syringe tip is the item that is used to spray air and water in a patient’s mouth during a dental treatment. Due to it’s simplicity, a dentist orthodontist, and hygienist overlook the cross-contamination ramifications that can occur from not properly sterilizing their metal air water syringe tips. Dentists, orthodontists, and hygienists have used metal air water syringe tips for over 40 years. In those 40 years, there have been many advances in scientific technology to help increase patient safety. Today, these same metal air water syringe tips are still a standard item in dental practices. The cleaning methods that are currently being administered have been proven to be ineffective. In the most recent 2013 study, a very alarming 10% of metal air water tips tested contained active live bacteria.
This is a serious health concern, and it is important for every dentist, orthodontist, and hygienist to understand the process by which this occurs.
THE BIRTH OF THE METAL AIR WATER SYRINGE TIP
Metal air water syringe tips are born clean and new with smooth channels inside, however, this pristine internal environment changes.
The act of sterilizing is very hostile and exposes the tip to high temperatures and disinfectants, which alter the tip by causing warping, corrosion, and other changes to the materials used to manufacture these tips. Metal air water syringe tips that have been re-processed many times often show visible signs of deterioration including discoloration and distortion.
This corrosive process creates a different environment inside the tip making it vulnerable to the collection of debris. An older tip and its micro-lumens can have pits, fissures, and other defects where bioburden is deposited.
Also known as aspiration or “suck-back”.
Bioburden enters metal air water syringe tips in several ways. It is important to remember that blood and other potentially infectious bodily fluids can be aerosolized when metal air water syringe tips are used to treat patients (hence the common use of face shields and barrier films today). Negative water pressure is generated in most air water syringes when the buttons are released to close valves inside the syringe. The physics of this action cause suck-back (reflux) into the metal air water syringe tips.
A quarter inch of blood, saliva, and tissue gets sucked into metal air water syringe tip.
Metal air water syringe tips are then placed into the ultrasonic solution. The ultrasonic fluid is not cleaned as often as it should, sometimes only once or twice a day!
A common practice in the sterilization process is to pre-clean instruments by placing them inside an ultrasonic bath before autoclaving. The disgusting fluid inside the ultrasonic machine is probably the most noxious area in a dental clinic. The ultrasonic is full of blood, saliva, bacteria, and other bioburden from all the patients that have had a treatment that day. This device is good at cleaning instruments on the outside; however, at the same time it introduces the contaminated fluid into the micro-lumens of metal air water syringe tips.
After metal air water syringe tips have been introduced with “suck-back” materials (blood, saliva, tissue), and after it is introduced to more biofilm and bacteria from other patients in the ultrasonic fluid, metal air water syringe tips are then placed inside an autoclave.
The standard autoclave uses heat and steam to sterilize the items placed inside. The problem is that the inside of metal air water syringe tips are not anodized. What this means is that the inside of the metal air water syringe tip corrodes each time it is put in the autoclave. As the corrosion continues, fissures begin to develop inside metal air water syringe tips. These fissures become pockets that collect biofilm, blood, tissue and other hazardous debris.
This collected debris begins to clog the tip. When metal air water syringe tips clog, the steam cannot penetrate all the way through these micro-lumens, causing a section of metal air water syringe tips to not get sterilized.
After this process has been completed, an unlucky patient then gets treated with the ineffectively sterilized metal air water syringe tip.
There have even been cases where debris inside metal air water syringe tips break off and gets shot into the patients’ mouth. Does that sound appealing to you? The sad thing is the average dentist, orthodontist, and hygienist know this, yet nothing is done to improve their infection control protocols and switch to disposable air water syringe tips.
Metal air water syringe tips are a difficult instrument to clean on the inside. The tip uses micro-lumens to deliver air, water, or air/water spray. The diameter of the micro-lumens is smaller than some hypodermic needles making them impossible to access. Dentists, orthodontists, and hygienists will notice that the performance characteristics of metal air water syringe tips degrade over time. The spray is visibly affected causing lower pressure, misdirected spray, and moisture problems while trying to deliver dry air during certain procedures.
NEW VS. OLD
METAL AIR WATER SYRINGE TIPS
Metal air water syringe tips begin to show signs of degradation after their very first use. As we discussed in the previous section of this page, metal air water syringe tips are impossible to clean.
Normal wear and tear accompanied by corrosion makes these tips very dangerous and we want to show you exactly what happens. We will begin by showing you the outside of metal air water syringe tips followed by what the inside of used metal air water syringe tips really look like. In order to show you these pictures we took a cross-section of a brand new metal air water syringe tip and a used metal air water syringe tip (consistently used for a 2 month period in a standard dental office). After visual inspection, you will see proof that these tips undergo rapid change after consistent use.
Remember, most dental offices use metal air water syringe tips for years before throwing them away due to clogging issues.
NEW AIR WATER SYRINGE TIPS
As you can see, new metal air water syringe tips start off looking very clean. The outside is polished with
a consistent color all the way through. You can also see the surfaces are clean with no fissures and no degradation.
OLD AIR WATER SYRINGE TIPS
On the other hand, the used metal tip already shows major signs of wear and tear. Parts of the metal have
already become chipped and discoloration has already begun to set in.
NEW AIR WATER SYRINGE TIPS
As you can see, new metal air water syringe tips don’t look that clean to begin with. The surfaces are
smooth, but it still does not look clean. If a patient could see this they would probably ask to have another
tip used for their procedure.
OLD AIR WATER SYRINGE TIPS
Used metal air water syringe tips look very dirty. As you can see, there is a lot of baked on debris and corrosion.
The baked on debris is so thick you cannot visually see the surfaces of the metal air water syringe tip.
As you can see, used metal air water syringe tips are full of baked on debris. What once was a smooth clean surface is now full of bioburden.
The debris you see baked into this tip all stems from the sterilization process. The reflux effect sucks 1/4 in. of aerosolized blood, saliva, and debris from a patient back into the tip. The ultrasonic fluid then fills the micro-lumens of the metal air water syringe tip with contaminated bacteria. And finally, all that bacteria, blood, saliva, and tissue gets baked into the tip by the autoclave. The end result of this process can be seen in these photos.
The metal air water syringe tip we used for this comparison was only used for two months. Just think what it would look like after 6 months, a year, or 5 years. A dentist, orthodontist, and hygienist tend to use their tips till they are completely clogged with this bioburden. Does the used metal air water syringe tip look like the sterilization process is effective?
Would you want this tip used on you or your family? We didn’t think so.
SCIENTIFIC STUDIES HAVE PROVEN
THERE IS NO EFFECTIVE WAY TO STERILIZE
METAL AIR WATER SYRINGE TIPS
Scientific studies done by multiple groups have shown that even when metal air water syringe tips are put through multiple sterilization cycles (standard dental offices put metal air water syringe tips through 1 cycle), of the tips tested, 10% still contain live active bacteria.
Now 1% would be enough to consider the sterilization cycle ineffective. But 10% is a shocking number for any type of device used for treatments where blood, saliva, and tissue are interacting. Over 20 years ago, after discovering metal air water syringe tips could not be properly sterilized, disposable (single-use) air water syringe tips were created as a safer alternative. The creation of single-use tips were suppose to eliminate dentists, orthodontists, and hygienists from using metal air water syringe tips. This is still not the case.
Disposable air water syringe tips are single-use tips that would be used as a replacement product for metal air water syringe tips. The purpose of disposable air water syringe tips was to eliminate cross-contamination and to ensure one tip was used on one patient. Once a disposable tip is used, it is then thrown away and a new tip would be used on the next patient.
Once again, the advancement in scientific technology helped solve another safety hazard. WRONG! Dentists, orthodontists, and hygienists from around the world are still using metal air water syringe tips in record numbers.
To view recent studies, please click on any of the links below.
Over 75% of dentists, orthodontists, and hygienists from around the world still use metal air water syringe tips. Even though a dentist, orthodontist, and hygienist have learned through scientific journals and studies that this item could be a hazard to patient safety, they continue to use them.
For over 20 years, dentists, orthodontists, and hygienists have turned a blind eye to using disposable air water syringe tips for reasons that would shock you. If a dentist, orthodontist, and hygienist is morally turning their back to doing something that would ensure their patients would receive a safe treatment, they must have a good reason not to… right?
Here are common excuses a dentist, orthodontist, and hygienist fall back on when asked about their continued use of metal air water syringe tips.
„Disposable tips are too expensive. I save money using metal air water syringe tips.“
„I’ve always used metal air water syringe tips. Why change now?“
„I am all about the environment. Disposable tips create a lot of unnecessary waste.”
„I have my staff clean the tips using ortho wire. I then purge the air and water lines and ensure everything is out of the tip.“
„We only use disposable air water tips on family, friends, and high-risk patients.“
„I haven’t killed anyone yet!“
Yes, Dentists, Orthodontists, and Hygienists Have Actually Said This.
Lets breakdown each excuse one-by-one.
Each excuse warrants some fears for the rationale a dentist, orthodontist, and hygienist is taking when deciding to NOT purchase a product that would ensure patients receive a safe dental treatment.
IT'S TOO EXPENSIVE
Some dentists, orthodontists, and hygienists believe they are saving money by re-processing tips. This may seem true at first, but when you take a closer look it is not a simple case of buy them once and you’ll decrease your overhead.
When confronted, a hygienist will admit that tips are replaced much more frequently than you might think. Metal air water syringe tips disappear into the trash, sink, drain, and ultimately every one of them will need to be replaced due to clogging. A clogged tip means bad dentistry and outcomes that will be impacted negatively, along with the obvious sanitary aspects. The cost to replace metal air water tips can range from $5 to well over $500 depending upon the air water syringe type. The overriding factor is that the safety of the patient is far more important than possibly saving some pennies.
If a patient knew what could be lurking inside metal air water syringe tips, then there is little doubt that they would gladly pay the extra $0.25 to receive a single-use tip. But most patients don’t know. And some dentists, orthodontists, and hygienists only have a vague awareness of what is going on inside the tip. Would a dentist, orthodontist, or hygienist place a visibly dirty dental instrument in front of the patient before starting treatment? No, they would not because the majority of patients would not accept.
Remember, it’s what can’t be seen on the inside of metal air water syringe tips that we’re talking about. In some cases, metal air water syringe tips have been attached to the delivery system for 10 years or more without EVER being autoclaved.
„Disposable air water syringe tips are too expensive. I save money using metal tips.”
WHY CHANGE NOW?
Usually this is a dentist, orthodontist, or hygienist that is stuck in their old ways. A few questions supplied will always shed some light on their misconceptions.
Back in the day, was it mandatory to wear gloves? Was it mandatory to wear a mask? No, these items were not mandatory, but as science and technology improved we learned that personal protective equipment was necessary to protect staff and patients from cross-contamination. The same goes for metal air water syringe tips.
New scientific studies have proven metal air water syringe tips are not safe, yet dentists, orthodontists, and hygienists continue to use them. As science and technologies improve, so do biofilms and viruses. New anti-biotic resistant viruses and biofilms mean we too need to create new ways of protecting ourselves. If metal air water syringe tips have been proven to have ineffective sterilization processes, doesn’t it only seem right to upgrade to a safer solution?
We find it hard for a dentist, orthodontist, and hygienist to sustain their argument when proven science shows they are wrong.
„I’ve always used metal air water syringe tips. Why change now?”
I CARE ABOUT THE ENVIRONMENT
The market for green products is still in it's infancy. Some dental offices claim they care about the environment, but when it comes to paying extra to get these products, all of a sudden their environmental stance seems to deteriorate.
Dentists, orthodontists, and hygienists claim they do not want to use disposable air water syringe tips because they have to throw away the tips after every patient. This in turn leads to an excess amount of waste that they feel is bad for the environment.
A dentist, orthodontist, and hygienist's number one priority should be the safety of their patient. Worrying about the environment as the forefront of their argument when they should be doing everything they can to protect their patients is a lapse in priorities. But at the same time, there are disposable air water syringe tips that are made from 100% compostable materials. These disposable air water syringe tips were created to help protect the environment while also protecting their patients.
As you can see, there are options for a dentist, orthodontist, and hygienist that are available, but again, it comes down to price. Currently a dentist, orthodontist, and hygienist will say they are all about “green” products until they see the price and fall back to their old ways. So again, there are options available for these dentists, orthodontists, and hygienist but they still choose to save a couple dollars over protecting their patients.
„I am all about the environment. Disposable air water syringe tips create a lot of unnecessary waste.”
I USE ORTHO WIRE
This statement is usually said when they have no logical argument. An ortho wire is a very thin wire that some dentists and orthodontists say they have their staff use to clean a metal tip.
First off, how many dentists or orthodontists allow their hygienist to spend hours trying to physically scrape a wire through each micro-lumen of a metal air water syringe tip? Depending on the metal air water syringe tip, there could be 4-8 lumens to clean, all of which are smaller than a hypodermic needle. Imagine, after each patient, a hygienist spending valuable time sitting there scrapping through a metal air water syringe tip. Do you think an office would follow these practices after every patient? Also, everyone knows that if you can’t see it, you can't clean it. We have previously discussed what happens inside of metal air water syringe tips. There is no possible way to see all the fissures and pockets where the bioburden builds up.
For arguments sake, let’s assume metal air water syringe tips have been adequately sterilized. Is there a difference between sterile and sanitary? You could make a mud pie in your yard and bake it in the oven for an hour at 425 degrees thereby ensuring it is sterile. But would you want to place it on the dinner table to share with your guests? The accumulated cooked debris that has collected inside metal air water syringe tips can most definitely be dislodged into the mouth of the next patient. It is important to emphasize that it is incorrect to assume metal air water syringe tips are sterilized. The efficacy of a sterilization cycle is dependent upon many variables including the condensation of vapors on the interior walls of the syringe micro-lumens. The vapors first need to penetrate a barrier (pouch or wrap) and then enter the metal air water syringe tip through tiny holes. To achieve proper sterilization, the vapor needs to condense on the walls of the micro-lumens for a period of time. The problem is that what once started as a smooth surface inside metal air water syringe tips has over time become compromised with additional surface areas that are difficult to reach due to corrosion and debris deposits.
„I have my staff clean metal air water syringe tips using ortho wire. I then purge the air and water lines and ensure everything is out of the tip.”
FRIENDS AND FAMILY ONLY
This argument is fundamentally wrong. When a dentist, orthodontist, or hygienist makes this statement, they are proving their belief that disposables are a safer alternative.
There are many offices that only carry a small supply of disposable air water syringe tips for specific purposes. These purposes include treatment of friends, family and high-risk patients. The rest of their patients are treated with metal air water syringe tips. How does that make you feel? If they are using these tips on loved ones and high-risk patients, why would they not choose to follow these same safety practices on you or your family? In their minds they've agreed that single-use air water syringe tips offer a higher level of safety, however, in practice they are violating your safety.
These actions also violate Universal Precautions. Universal Precautions as defined by the CDC and OSHA essentially states that all patients should be treated with the assumption that they are infected. The presumed infection could be mild like the flu virus or something much more serious. In fact, some of you reading this right now might be infected with something and not know it. Some people can be asymptomatic so they would have no reason to believe they are sick. There are other infected people that know they are carriers, but do not disclose their condition with healthcare providers.
On your next visit, please ask your dentist, orthodontist, or hygienist how he/she defines whose life is valuable enough for disposable air water syringe tips.
„We only use disposable air water syringe tips on family, friends, and high-risk patients.”
I HAVEN’T KILLED ANYONE YET
You would be surprised at the frequency in which this comment is made. Even saying this as a joke is not funny.
Infection control is a serious matter and a dentist, orthodontist, or hygienist that holds this opinion is not likely to be looking out for your best interest. If they hold this opinion of air water syringe tips, what other items do they also overlook as being a “non-issue”? For these types of dentists, orthodontists, and hygienists there are no studies, examples, or technologies that will sway them from their abrasive stance on infection control.
There have been many recent news stories that say the opposite to this argument. Patients are getting sick daily from dentists, orthodontists, and hygienists who do not follow safety protocols. The sad situation is that unless a disgruntled employee or patient raises concern, these stories are never brought to light. With the lack of mandated health inspections, a dentist, orthodontist, and hygienist are left on their own to determine their own safety protocols. Until dental offices are regularly inspected, there is no way to determine how safe a dental office really is.
If you visit a dentist, orthodontist, or hygienist who uses this argument...
„I haven’t killed anyone yet.”
If you would like to request samples of disposable air water syringe tips to bring to your next dental
appointment, please contact us and we will send you FREE samples, NO PURCHASE NECESSARY.
WHAT DO LEADING HEALTH
Health authorities from around the world set many recommendations for sterilization processes, but when an item is difficult to clean, single-use products should be used.
IT’S TIME TO OPEN YOUR EYES
The information and excuses you have just read should open your eyes when visiting a dental office. Just because the office looks clean, does not mean you cannot get sick or contract a deadly disease.
Metal air water syringe tips have been proven to not be safe. This is not someone saying that, this is science, technology, and research that have all proven this to be a fact. For over 20 years now, dentists, orthodontists, and hygienists have fought science and technology to switch from metal air water syringe tips to disposable tips based on the above arguments. At what point does this become a moral obligation for a dentist or orthodontist? If a dentist or orthodontist knows something is not safe, but does not inform his or her patients before treating them, that is breaking patient trust, informed consent, and a dentist/orthodontist's oath to provide a safe dental treatment.
We urge you as dental patients to observe and ask the right questions on your next dental visit. When it comes to the safety of you or your family, knowing the facts is half the battle. Being armed with this knowledge allows you to protect yourself when your dentist, orthodontist, or hygienist engages in bad infection control habits. We want everyone to receive a safe dental treatment and the only way this is possible is to allow you, the public, to become aware of things you were not privy to. Disposable air water syringe tips should be a requirement, not a choice. Dentists, orthodontists, and hygienists have plenty of options when selecting disposable air water syringe tips and the time of trying to save money over patient safety has to stop.
Explaining the facts is our main goal at Dentistry’s Dirty Secret. Consumer advocacy along with aggressive education of dental professionals will help drive the change needed to ensure the highest level of sanitation.
Air water syringe tips are only half the problem. The air water syringe, where the air water syringe tip is
inserted into, also has many fundamental infection control issues.